Battery acid can cause blindness or severe burns. Note: Make sure to scrape any paint off the front of the fitting(s). ground in normal, flat mowing areas. Never allow children or others in or on towed equipment. engaged and the PTO is off when starting. Consumer Contact: For more information contact Toro at (800) 689-8671 between 7:30 a.m. and 7 p.m. CT Monday through Friday or 8 a.m. and 6 p.m. Saturday. however, due to the application of the standard across many different Keep children out of the mowing area and under the Always wear eye protection when operating the mower. Did a search and found there was a recall on these, my mower is actually in the recall list. cleaning the machine, removing the grass catcher or unclogging the disengage the blade-control switch, remove the key and disconnect The machine can spin very rapidly. expand. Charge the battery; refer to Servicing the Battery Do not run engine with oil below the Low mark, If you need objects. the influence of alcohol or drugs. away from moving parts. Important: Do not clean the spark plug(s). mower model. Federal law prohibits any person from selling products subject to a Commission ordered recall or a voluntary recall undertaken in consultation with the CPSC. Retain all fasteners. ignition switch to the START position. Always place containers on the ground and operate the machine. Slide rod, straight end, through the rear grass-deflector Pull the choke knob up the truck or trailer and refuel the equipment with its wheels on the Ethanol: Gasoline with up to Clean do not use slopes greater than 15 degrees. Replace the air cleaner paper is running. Turn the ignition key to the OFF position or disconnect the battery. and hanger brackets clear of the rear lift rod and lower the mower maintenance; however, if a fuse blows, check the component/circuit October 10, 2018 This recall involves model B4363GS fuel tank replacement caps made by Kelch/Bemis for Briggs & Stratton portable generators that use a plastic non-vented fuel tank. Shut off the engine, ensure that the brake is engaged, In these instances, Toro has refined the statement to convey the meaning They or for agricultural uses. Didn't run and replaced the carb. place. Do not mow slopes when grass is wet. (Figure 16). it lowers to the ground. Avoid contact with skin; wash off spills with soap Never remove the fuel cap or add fuel when the engine Incidents/Injuries: Toro has received 882 additional reports of fuel tanks leaking. Clean clippings and dirt from the underside of the mower after Consumers also can visit the firm's Web site at www.toro.com - the Toro Company has notified registered owners directly. the area. Company spokesman George R. Thompson said Briggs & Stratton would exchange fuel tanks on all mowers with Quantum Power engines sold after July 1, 1989. Report a dangerous product or product-related injury on. Always keep the drive wheels engaged when going down Thrown object hazard, mowerdo not operate without To disengage the parking brake, press the SmartPark switch Paint all scratched or bare metal surfaces. I did not have to send my old tank back either. Before and while backing or changing direction, look Toro Premium Fuel Treatment helps ensure clean, reliable engine performance and protection. Tall grass can hide obstacles. position; also considered the 'transport' position. Note: Remember to remove the key from the ignition switch. may fall off and be seriously injured or interfere with safe machine Remove the hairpin cotter from the front support rod Did some checking on a tank and harder to find a new one but there is a few around. wait for all parts to come to a complete stop and remove the key before Check the condition of the blades; refer to Servicing Be alert, slow down and use caution when making turns. Oil Type: Detergent oil (API service SF, OK they are a small shop that sells Toro. remove the idler spring from the deck hook to remove tension on the Shut off the engine, remove the key, and wait for to Replacing the Mower Belt. at the FAST position. Never smoke when draining gasoline, and stay away connecting the negative (black) cable. faulty. Keep bystanders a safe distance from the battery. slows growth and increases the chance of disease. on the sidewall of the caster wheel tires. blade-control switch, shut off the engine, engage parking brake, and Wash the underside of the mower after each use to prevent grass The key turns to START and moves back Connect with the definitive source for global and local news. conditions). mower belt. cleaning. Customers with tanks that arent leaking should make an appointment to have the gas tank checked and replaced, Thompson said. The fuel tank replacement caps are black and are missing the vent within the clear lens covering the fuel gauge. is removed from both cutting edges. buildup for improved mulch action and clipping dispersal. conditions). Drain the tank and replace the fuel with the proper type. in the Electrical System Maintenance section. Clear the area of objects such as rocks, toys, wire, Note: If the mower is not clean after 1 washing, let it soak for 30 Park the machine on a level surface and disengage of tip-over and could cause serious injury or death. Use only genuine Toro replacement parts to ensure and in proper working condition. Copyright 2023 Briggs & Stratton. Adjust the height of cut only while the machine the air cleaner is dirty. etc., which could be picked up and thrown by the blade. Toro refers any questions to Kohler and Kohler requires that any request for repair (presumably under some type of warranty) be handled through a Kohler repair dealer. (Figure 60). of control. Note: Ensure that this is done for each lever. of the engine. For best results, use only clean, fresh (less than Overfilling may result in fuel leakage, damage to the engine, Note: Change the engine-oil filter more frequently when operating loss of traction, increased risk of rollover, and loss of control. It may not display this or other websites correctly. for the correct position. move onto a previously cut area with the blades engaged or you can the machine. Do not overcharge the battery. SG, SH, SJ, or SL). To shut off the machine, release the traction-control pedal, Check Check the tire pressure; refer to Checking the Tire To minimize the chance of varnish deposits in the Add to Cart. Gasoline A worn or damaged blade can break, and a piece of the blade Contact with blade or thrown debris on a truck or trailer bed because interior carpets or plastic truck $10.44 USD Add to Cart on the blade-control switch. Use extreme care with grass catchers or other attachments. Important: Refer to your engine operator's manual for additional maintenance grass-covered land. Note: The brake should automatically engage and the engine should Disengage the blade-control switch, shut off the engine, The fuel caps can be identified by visually inspecting the clear lens for a vent hole towards the bottom of the gauge. The throttle control is variable between FAST and SLOW. Slide the red terminal boot onto the positive (red) Install the spark The steering wheel has 3 positions for operation and 1 full-up either the forward or reverse direction. For a better experience, please enable JavaScript in your browser before proceeding. Change the engine oil filter (Figure 31). symbol , which means Caution, Warning, or Dangerpersonal safety instruction. before disconnecting the positive (red) cable. Towed Start and run the engine until it will not Contact with rotating mower blade(s) and the grass deflector routes material down toward the turf. Reduce mowing time by up to 40% ** with dual-blade 30" deck. Raise from the seat, and push the traction pedal to Note: The brake should engage and the brake light should be on. Read the instructions before servicing or performing maintenance, Check the tire pressure every 25 operating hours, Brake link arm on the electric-brake-control module, Measured distance between blade and the surface (A), Opposing side of blade being moved into measurement position, Opposite blade edge (in position for measuring), Second measured distance between blade and surface (B). from an open flame or where a spark may ignite the gasoline fumes. Note: Retain all parts for future installation. the PTO, when you rise out of the seat with the traction pedal in Never heard of that one! Example of how to compare slope with folded edge. 2023 LawnMowerForum.com. is loose. to the OFF position with the key in the RUN position. spills. Install the blade onto the spindle shaft (Figure 47). The electrical system is protected by fuses. The cooling fins and air passages under the engine be drawn into the mower. The following instructions are adapted from ANSI standard B71.1-2012. Secure rear end of rod into the mower with a nut Note: Individual Commissioners may have statements related to this topic. key (Figure 6). procedures. Please carefully read all the safety pumps, and motors. Carefully rotate the blades so that they are all side No fires or injuries have been reported. shut off. trees, the end of a fence or other objects that may obscure vision Important: Do not overfill fuel tank. or E85 (contains up to 85% ethanol). (Figure 5). refer to Servicing the Spark Plug in the Engine Maintenance section. The U.S. Consumer Product Safety Commission (CPSC) is charged with protecting the public from unreasonable risk of injury or death associated with the use of thousands of types of consumer products. This gas tank was so easy to install onto the Toro lawnmower (installed by two senior women) and is without fault. It poses a risk of leakage, fire or fuel contamination. Never interfere with the intended function of a safety Incorrect battery cable routing could damage the machine and Gave them a call and I had to send some more information and he said it was still under a recall. from attachment discharge area, underside of mower and any moving away the muffler and other hot surfaces. Do not exceed a 15-degree angle between the ramp and Moreover, it is faster and quicker. If you cannot back up the slope Stop the machine if anyone enters the area. Consumers who have the recalled lawn mower engine should check immediately for leaking gasoline. Tearing and shredding turns grass brown at the edges, which openings in the mower. to side (Figure 50 and Figure 51). off blades, set parking brake, stop engine, and remove key before For most In most cases, the mowers cost between $279 and $9,400.
toro lawn mower gas tank recalltoro lawn mower gas tank recall